Troubleshooting Yamaha outboard engines for 1984-2006 Yamaha outboard motors, download a service manual instantly.


Downloads in Seconds!

DOWNLOAD A YAMAHA OUTBOARD ENGINE SERVICE MANUAL STRAIGHT TO YOUR COMPUTER IN JUST SECONDS!

VIEW A SAMPLE PAGE OF A TYPICAL PDF SERVICE MANUAL

HERE

 SELECT YOUR YEAR AND MODEL OUTBOARD ENGINE BELOW

 

The Yamaha outboard motor service manual downloads for the above listed models describes the service procedures for the complete engine. Follow the Maintenance Schedule recommendations to ensure that the motor is in peak operating condition and the emission levels are within the standards set by the your states/county Resources Board. Performing the scheduled maintenance is very important. It compensates for the initial wear that occurs during the life of the outboard motor.
 
All chapters in the Yamaha service manuals apply to the whole engine and illustrates procedures for removal & installation of components that are in detailed step-by-step fashion.
 
Most all service manual chapters start with an assembly or system illustration, diagrams, exploded parts view, quality pictures, service information and troubleshooting for the section. The subsequent pages give detailed procedures. If you don’t know the source of the trouble, go to the troubleshooting page for a list of causes and effects to determine the problem at the end of the manual.

 

TROUBLESHOOTING - GENERAL

FUEL SYSTEM TROUBLESHOOTING

Throttle is “rolled back” or closed, thereby actuating idle cable roll-off (disengage) switch.

The cruise module circuitry provides on-board diagnostics to help isolate any problems that might occur with the cruise system.

See Starting & Charging System Troubleshooting in Service Manual.

The ECM is monitoring voltage at ECM connector terminal 35.

This checks for voltage drops in the ECM power circuit. If a significant voltage drop is not present, condition may be caused by excessive starter current draw.

See Electrical Relays, Removal/Installation in the Yamaha Service Manual.

Plug Fouling Due to Engine Mechanical Fault.

Use the troubleshooting tables on the following pages to diagnose and locate problems with malfunctioning or inoperative instruments and gauges. For wire connections at rear of gauges refer to the applicable wiring diagram at the back of this book for further assistance.

Follow the troubleshooting procedures listed under (carbureted) or (EFI) if the engine will not start, is difficult to start or runs roughly. Also check condition of spark plug cables. Insulation on cables may be cracked or damaged allowing high tension current to short to metal parts. This problem is most noticeable when cables are wet. If poor starting/running condition persists, check resistance of ignition coil primary and secondary windings using an ohmmeter.

TROUBLESHOOTING

When the charging system fails to charge or does not charge at a satisfactory rate, make the following recommended checks.

Battery

Check for a weak or dead battery. Battery must be fully charged in order to perform any electrical tests.

Wiring

Check for corroded or loose connections in the charging circuit.

Voltage Regulator Inspection

The regulator must have a clean, tight ground connection for proper operation. Check by using an ohmmeter with one lead on the battery ground cable and the other on the regulator ground terminal (on left side ground post in front of battery). Connector plug at engine crankcase must be clean and tight.

POOR HIGH SPEED PERFORMANCE

Check for:
1. Inlet system air leak.
2. Enrichener valve not seated or leaking.
3. Restricted fuel tank vent system.
4. Restricted fuel supply tract.
5. Dirty or damaged air cleaner element.
6. Plugged bowl, vent or overflow.
7. Worn or damaged needle or needle jet.
8. Vacuum piston assembly malfunction.
9. Loose or plugged main jets or passages.
10. Improper fuel level.
11. Accelerator pump inoperative.

POOR PERFORMANCE AT IDLE

1. Idle speed improperly adjusted.
2. Inlet system air leak.
3. Restricted fuel tank vent system.
4. Dirty or damaged air cleaner element.
5. Enrichener valve not seated or leaking.
6. Restricted fuel supply tract.
7. Plugged bowl vent or overflow.
8. Loose or plugged fuel and air jets or passages.
9. Worn or damaged needle or needle jet.
10. Vacuum piston assembly malfunction.
11. Accelerator pump inoperative.

HARD STARTING

Check for:
1. Enrichener system plugged, not properly functioning or improperly operated.
2. Inlet system air leak.
3. Restricted fuel supply.
4. Fuel overflow.
5. Plugged slow jet or passages.

POOR ACCELERATION

Check for:
1. Throttle cables misaligned.
2. Inlet system air leak.
3. Restricted fuel tank vent system.
4. Restricted fuel supply passages.
5. Plugged bowl vent or overflow.
6. Enrichener valve not seated or leaking.
7. Worn or damaged needle or needle jet.
8. Vacuum piston malfunction.
9. Plugged jets or passages.
10. Fuel level (float chamber) too low.
11. Accelerator pump leaking or no output.

POOR FUEL ECONOMY

Check for:
1. Excessive use of enrichener system.
2. Enrichener valve not seated or leaking.
3. Dirty air cleaner element.
4. Restricted fuel tank vent system.
5. High speed riding style.
6. Idle speed improperly adjusted.
7. Loose jets.
8. Fuel level too high.
9. Plugged or restricted bowl vent.
10. Worn or damaged needle or needle jet.
11. Vacuum piston assembly malfunction.
12. Plugged air jets or passages.
13. Excessive accelerator pump output.

POOR IDLING

Check for:
1. Idle speed improperly adjusted.
2. Inlet system air leak (faster idling).
3. Loose low speed jet.
4. Contaminated or plugged low speed system.
5. Enrichener valve not seated or leaking.
6. Leaking accelerator pump.

CARBURETOR TROUBLESHOOTING OVERFLOW

Check for:
1. Restricted fuel tank vent system.
2. Loose float bowl screws.
3. Damaged float bowl O-ring.
4. Damaged or leaking float assembly.
5. Particle contamination in fuel inlet fitting cavity.
6. Worn or dirty inlet valve or seat.
7. Improper fuel level in float bowl.

High Oil Pressure

1. Oil pan overfilled.
2. Oil pressure relief valve stuck in closed position.

Engine Leaks Oil From Case, Push Rods, Hoses, Etc.

1. Loose parts.
2. Imperfect seal at gaskets, push rod cover, washers, etc.
3. Restricted oil return line to pan.
4. Restricted breather hose to air cleaner.
5. Restricted oil filter.
6. Oil pan overfilled.
7. Rocker housing gasket (bottom) installed upside down.

Low Oil Pressure

1. Oil pan underfilled.
2. Faulty low oil pressure switch.
3. Oil pump O-ring(s) damaged or missing.
4. Oil pressure relief valve stuck in open position.
5. Ball missing from cam support plate.

Valve Train Noise

1. Low oil pressure caused by oil feed pump not functioning properly or oil passages obstructed.
2. Faulty hydraulic lifters.
3. Bent push rod.
4. Incorrect push rod length.
5. Rocker arm binding on shaft.
6. Valve sticking in guide.
7. Chain tensioner spring or shoe worn.

Overheating

1. Insufficient oil supply or oil not circulating.
2. Insufficient air flow over engine.
3. Heavy carbon deposit.
4. Ignition timing retarded due to faulty MAP, CKP and/or CMP Sensors.
5. Leaking valve.

Engine Uses Too Much Oil Or Smokes Excessively

1. Oil pan overfilled.
2. Restricted oil return line to pan.
3. Restricted breather operation.
4. Restricted oil filter.
5. Piston rings badly worn or broken.
6. Valve guides or seals worn.
7. O-ring damaged or missing from oil pump/crankcase junction (also results in poor engine performance).

Pre-Ignition or Detonation (Knocks or Pings)

1. Fuel octane rating too low.
2. Faulty spark plugs.
3. Incorrect spark plug for the kind of service.
4. Excessive carbon deposit on piston head or in combustion chamber.
5. Ignition timing advanced due to faulty sensor inputs (MAP, CKP, CMP).

LUBRICATION SYSTEM

Oil Does Not Return To Oil Pan

1. Oil pan empty.
2. Oil pump not functioning.
3. Restricted oil lines or fittings.
4. Restricted oil filter.
5. O-ring damaged or missing from oil pump/crankcase junction (also results in poor engine performance).

A Spark Plug Fouls Repeatedly

1. Fuel mixture too rich or enrichener left out too long.
2. Incorrect spark plug for the kind of service.
3. Piston rings badly worn or broken.
4. Valve guides or seals badly worn.

Engine Turns Over But Does Not Start

1. Fuel tank empty.
2. Fuel supply valve turned to OFF.
3. Fouled spark plugs.
4. Engine flooded with gasoline as a result of over use of enrichener.
5. Fuel valve or filter clogged.
6. Vacuum hose to automatic fuel supply valve disconnected, leaking or pinched.
7. Discharged battery, loose or broken battery terminal connections.
8. Loose wire connection at coil, battery or plug between ignition sensor and module.
9. Spark plug cables in bad condition and shorting, cable connections loose, or cables connected to wrong cylinders.

Starts But Runs Irregularly or Misses

1. Spark plugs in bad condition or partially fouled.
2. Spark plug cables in bad condition and leaking.
3. Spark plug gap too close or too wide.
4. Faulty ignition coil, module and/or sensor.
5. Battery nearly discharged.
6. Damaged wire or loose connection at battery terminals, ignition coil, or plug between ignition sensor and module.
7. Intermittent short circuit due to damaged wire insulation.
8. Water or dirt in fuel system, carburetor or filter.
9. Fuel tank vent system plugged or carburetor vent line closed off.
10. Carburetor controls misadjusted.
11. Damaged carburetor.
12. Loose or dirty ignition module connector at crankcase.

Starter Motor Does Not Operate or Does Not Turn Engine Over

1. Ignition/Light Key Switch not in IGNITION position.
2. Engine Stop switch in the OFF position.
3. Discharged battery, loose or corroded connections (solenoid chatters).
4. Bank Angle Sensor tripped and Ignition/Light Key Switch not cycled to OFF and then back to IGNITION.
5. Starter control circuit, relay or solenoid faulty.
6. Electric starter shaft pinion gear not engaging or overrunning clutch slipping.

Starts Hard

1. Spark plugs in bad condition, have improper gap or are partially fouled.
2. Spark plug cables in bad condition.
3. Battery nearly discharged.
4. Loose wire connection at one of the battery terminals, ignition coil or plug between ignition sensor and module.
5. Carburetor controls not adjusted correctly.
6. Water or dirt in fuel system and carburetor.
7. Intake air leak.
8. Fuel tank vent hose and vapor valve plugged, or carburetor fuel line closed off and restricting fuel flow.
9. Enrichener valve inoperative.
10. Engine lubricant too heavy (winter operation).

NOTE Always disengage clutch for cold weather starts.

11. Ignition not functioning properly (possible sensor failure).
12. Faulty ignition coil.
13. Valves sticking.

The following check list of possible operating troubles and their probable causes will be helpful in keeping your motorcycle in good operating condition. More than one of these conditions may be causing the trouble and all should be carefully checked.

The troubleshooting section of this manual is intended solely as a guide to diagnosing problems. Carefully read the appropriate sections of this manual before performing any work. Improper repair and/or maintenance could result in death or serious injury.

1. Tapered Keepers
2. Spring Retainer
3. Inner Spring
4. Outer Spring
5. Valve Stem Seal
6. Spring Seat
7. Valve Guide
8. Cylinder Head Bolt
9. Cylinder Head Bolt
10. Cylinder Head
11. Valve Seat
12. Valve
13. Cylinder Head Gasket
14. Cylinder
15. O-Ring
16. Ring Dowel
17. O-Ring Seal
18. Cylinder Stud
19. Piston
20. Piston Pin
21. Circlip
22. Top Compression Ring
23. Second Compression Ring
24. Oil Rail
25. Oil Rail Spacer

1984-1994 Yamaha Outboard Service Manual/WorkShop Manual Application: 2 hp 1 cyl. (43cc) 2-stroke 1984 1994, 3 hp 1 cyl. (70cc) 2-stroke 1989, 3 hp 1 cyl. (70cc) 2-stroke 1990 1994, 4 hp 1 cyl. (83cc) 2-stroke 1984 1994, 5 hp 1 cyl. (103cc) 2-stroke 1984 1994, 6 hp 2 cyl. (165cc) 2-stroke 1986 1994, 8 hp 2 cyl. (165cc) 2-stroke 1984 1994, 9.9 hp 2 cyl. (246cc) 2-stroke 1984 1994, 9.9 hp 2 cyl. (232cc) 4-stroke 1984 1994, 15 hp 2 cyl. (246cc) 2-stroke 1984 1994, 25 hp 2 cyl. (395cc) 2-stroke 1988 1994, 25 hp 2 cyl. (430cc) 2-stroke 1990 1994, 25 hp 2 cyl. (496cc) 2-stroke 1984 1994, 28 Jet 3 cyl. (698cc) 2-stroke 1990 1994, 30 hp 2 cyl. (496cc) 2-stroke 1984 1994, 30 hp 3 cyl. (496cc) 2-stroke 1987 1994, 35 Jet 3 cyl. (698cc) 2-stroke 1987 1994, 40 hp 2 cyl. (592cc) 2-stroke 1989 1994, 40 hp 3 cyl. (698cc) 2-stroke 1984 1994, 50 hp 3 cyl. (698cc) 2-stroke 1984 1994, 50 hp 3 cyl. (849cc) 2-stroke 1994 1994, 55 hp 2 cyl. (760cc) 2-stroke 1989 1994, 60 hp 3 cyl. (849cc) 2-stroke 1991 1992 1993 1994, 65 Jet 3 cyl. (1140cc) 2-stroke 1987 1994, 70 hp 3 cyl. (849cc) 2-stroke 1984 1985 1986 1987 1988 1989 1990 1991 1992 1993 1994, 75 hp 3 cyl. (1140cc) 2-stroke 1994, 80 hp 3 cyl. (1140cc) 2-stroke 1994, 80 Jet V4 (1730cc) 2-stroke 1987 1994, 85 hp 3 cyl. (1140cc) 2-stroke 1989 1994, 90 hp 3 cyl. (1140cc) 2-stroke 1984 1994, 115 hp V4 (1730cc) 2-stroke 1984 1994, 130 hp V4 (1730cc) 2-stroke 1988 1994, 140 hp V4 (1730cc) 2-stroke 1984 1994, 140 Jet V6 (2596cc) 2-stroke 1987 1994, 150 hp V6 (2596cc) 2-stroke 1984 1994, 175 hp V6 (2596cc) 2-stroke 1984 1994, 200 hp V6 (2596cc) 2-stroke 1984 1994, 220 hp V6 (2596cc) 2-stroke 1984 1985 1986 1987, 225 hp 76 deg. V6 (3130cc) 2-stroke 1994, 225 hp 90 deg. V6 (2596cc) 2-stroke 1987 1988 1989 1990 1991 1992 1993 1994, 250 hp V6 (3130cc) 2-stroke 1990 1994

LIT-18616-01-24 Service Manual Application: Yamaha Ouboard 9.9HP (9.9-HP) 4-stroke engines. Model Names: T9.9T (T9.9-T), F9.9T (F9.9T), T9.9MH (T9.9-MH), F9.9AM (F9.9-AM), F9.9AEM (FT9.9-AEM), T9.9ER (T9.9-ER), F9.9AE (F9.9-AE), F9.9MH (F9.9-MH), F9.9BM (F9.9-BM), T9.9EH (T9.9-EH), F9.9BEM (F9.9-BEM), F9.9BE (F9.9-BE).

LIT-18616-01-28 Service Repair Manual Application: 1995, 1996, 1997 (95, 96, 97) Yamaha Marine Outboard E48T (E48-T) C55T (C55-T) 48HP & 55HP 2-Stroke. Item Model Names: E48T, C55T, E48C, E48MH, E55C, 55BM, C55ER, 55BE, 55BEM, C55TR, 55BET.

LIT-18616-01-35 Service Manual Application: 1996-1997 Yamaha F8, T9.9, F9.9 8HP (8-hp) & 9.9Hp (9.9-hp) 4-stroke engines. Exact Models Covered (Covers All 1996-1997 Models World Wide): F8B (F8-B), F9.9A (F9.9-A), F9.9B (F9.9-B), T9.9U (T9.9-U), F9.9U (F9.9-U), F8BM (F8-BM), F8BEM (F8-BEM), F8BE (F8-BE), T9.9MH (T9.9-MH), T9.9AM (T9.9-AM), FT9.9AMH (FT-9.9-AMH), T9.9EH (T9.9-EH), F9.9AEM (FT9.9-AEM), T9.9ER (T9.9-ER), FT9.9AE (FT9.9-AE), F9.9MH (F9.9-MH), F9.9BM (F9.9-BM), F9.9EH (F9.9-EH), F9.9BEM (F9.9-BEM), F9.9BE (F9.9-BE).

LIT-18616-01-29 Service Repair Manual Application: 1996, 1997 (96, 97) E60, E60H 60HP (60-HP) Yamaha Marine Outboard 2-Stroke. Item Model Names: E60, E60H, E60HM, E60HE, E60HEM, E60MH, E60EH. Covers USA, Canada and wold wide models.

LIT-18616-01-73 Service Repair Manual Application: 1997 97' Yamaha Marine Outboard 75HP (75HP) 2-Stroke. Item Model Names: E75V, E-75-V, E75-V, E-75V 75AM, 75AEM, 75AE, 75AET, 85AEM, 85AE, 85AET, E75B, E60J, E75MH. Covers USA, Canada and wold wide models.

LIT-18616-01-66 Service Repair Manual Application: 1997-1998 Yamaha Marine Outboard 20HP (20-HP) & 25HP 25-HP) 10V, 25V, 25V2 2-Stroke Engines. Model Names 20DM (20-DM), 20DMO (20-DMO), 20DEM (20-DEM), 20DEMO (20-DEMO), 20DERO (20-DERO), 20MH (20-MH), 20MH2 (20-MH2), 20EH (20-EH), 20EH2 (20-EH2), 25DM (25-DM), 25NMO (25-NMO), 25NEMO (25-NEMO), 25NE (25-NE), 25NEO (25-NEO), 25NERO (25-NERO), 25MH (25-MH), 25MH2 (25-MH2), 25EH (25-EH), 25ER (25-ER).

LIT-18616-01-81 Service Repair Manual Application: 1998-1999 98-99 40HP (40-HP) & 50HP (50-HP) 40W 50W Yamaha Marine Outboard 2-Stroke Item Model Names: 40-W, 50-W, 40VMH, 40VMHD, 40VMHO, 40VMO, 40VWH, 40VE, 40VEO, 40VEHTO, 40VET, C40MH, 40MH, C40ER, 40ER, P40TH, C40TR, 40VETO, 50HMHO, 50HMHD, 50HMO, 50HMDO, 50HWHD, 50HEDO, 50HET, 50HETO, 40TR, 50ER, C50TR, 50TR Covers USA, Canada and wold wide models.

LIT-18616-F1-50 & LIT-18616-02-12 Service Repair Manual Application: 1998-2005 Yamaha Marine Outboard 15HP (15-HP) 4-Stroke Engines F15W (F15-W), F15Z (F15-Z) 1998, 1999, 2000, 2001, 2002, 2003, 2004 & 2005. This manual covers all 15HP 4-Stroke models world wide including USA CANADA. USA & CANADA MODELS: F15MHW (F15-MHW), F15EHW (F15-EHW), F15AMH (F15-AMH), F15AEH (F15-AEH), F15AEP (F15-AEP), F15AEHP (F15-AEHP), F15PR (F15-PR), F15PH (F15-PH), F15AEP (F15-AEP), F15AEHP (F15-AEHP). WOLD WIDE MODELS: F15AMH (F15-AMH), F15AEH (F15-AEH), F15AE (F15-AE).

LIT-18616-01-83 Service Manual Application: 1998-2006 Yamaha F8, T9.9, F9.9 8HP (8-hp) & 9.9Hp (9.9-hp) 4-stroke engines for 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005 & 2006. Model Name: T9.9W (T9.9-W), F9.9W (F9.9-W), F8BMH (F8-BMH), F8BEH (F8-BEH), F8BE (F8-BE), T9.9MH (T9.9-MH) FT9.9AMH (FT-9.9-AMH), T9.9EH (T9.9-EH), FT9.9AEH (FT9.9-AEH), T9.9ER (T9.9-ER), FT9.9AE (FT9.9-AE), F9.9MH (F9.9-MH), F9.9BMH (F9.9-BMH), F9.9EH (F9.9-EH), F9.9BEH (F9.9-BEH), F9.9BE (F9.9-BE).

LIT-18616-01-79 Service Repair Manual Application: 1998-2005 Yamaha Marine Outboard 4HP (4-HP) 4-Stroke Engines F4X (F4-X, F-4X) 1999, 2000, 2001, 2002, 2003, 2004 & 2005. This manual covers all 4HP 4-Stroke models world wide including F4MSHX, F4MLHX, F4AMH, USA CANADA.

LIT-18616-01-94 Service Repair Manual Application: 1999-2000 99-00 25HP (25-HP) & 30HP (30-HP) 25X, 25-X, 30X, 30-X, 25J, 25-J, 30D, 30-D Yamaha Marine Outboard 2-Stroke. Model Names: 25JMH, 25MH3, 30DMH, 25JMHO, 30DMHO, 30MH, 25JEHO, 25EH3, 30DWH, 25JEO, 25JETO, 25TR3, 30DEHO, 30EH, 30DMO, 30DE, 30DEO, 30ER, 30DET, 30DETO, 30TR Covers USA, Canada and wold wide models.

LIT-18616-01-96 Service Repair Manual Application: 1999, 2000, 2001, 2002 99, 00, 01, 02 100HP (100-HP) F100X, F100-X, F-100X Yamaha Marine Outboard 4-Stroke. Model Names: F100TR, F100-TR, F-100TR, F100AET, F-100AET, F100-AET Covers USA, Canada and woldwide models.

LIT-18616-02-16 Service Repair Manual Application: 2000, 2001, 2002, 2003, 2004, 2005, 2006, 00, 01, 02, 03, 04, 05, 06 Yamaha Marine Outboard 40HP (40-HP) F40B (F-40B-F40-B) 4-Stroke Engines. Model name F40BMHD, F40BWHD, F40BED, F40BET, USA and Canada name F40MH, F40ER, F40TR.

LIT-18616-02-19 Service Repair Manual Application: 2001, 2002, 2003, 2004, 2005, 2006, 01, 02, 03, 04, 05, 06, Yamaha Marine Outboard 6HP & 8HP (F6Z F8Z) 4-Stroke Engines. Model Name: F6AMH, F8CMH, F6MH, F8MH (F6-AMH, F6-MH, F8-AMH, F8-MH).

ALL 250HP 2003-2006 MODELS Service Repair Manual Application: 2003, 2004, 2005, 2006 Yamaha Marine Outboard 250HP (250-HP) 2-Stroke & 4-Stroke Engines. LIT-18616-02-78 -  2004-2005 Z250C & LZ250C LZ250TR 2-STROKE ENGINE. LIT-18616-02-43 - 2003-2005 Z250B & LZ250B MODEL NAME Z250TR/LZ250TR 2-STROKE ENGINE. LIT-18616-02-97 - 2005-2006 F250 & LF250 F250TR/LF250TR 4-STROKE ENGINE. 

LIT-18616-02-54 Service Repair Manual Application: 2004, 2005, 2006 Yamaha Marine Outboard 2.5HP (2.5-HP) F2.5C (F2.5-C, F 2.5C) F2.5MH 4-Stroke Engines.

LIT-1816-02-59 Service Repair Manual Application: 2004, 2005, 2006 Yamaha Marine Outboard 9.9HP & 15HP (9.9-HP 15-HP) 2-Stroke Engines. Model name 9.9CMH & 15CMH ( 9.9 & 15 CMH).

LIT-18616-02-61 Service Repair Manual Application: 2004-2006 Yamaha Marine Outboard 25HP (25-HP) 4-Stroke Engines F25C, T25C (F-25C F25-C T25-C T-25C) F25MH, F25EH, F25ER, F25TR, T25TR.

LIT-18616-02-65 Service Repair Manual Application: 2004-2006 Yamaha Marine Outboard 40HP (40-HP) & 50HP (50-HP) 4-Stroke Engines. Exact model name 40VETO 50HETO, Both USA and CANADA models covered 40TR 50TR / 40C-50C.

LIT-18616-02-66 Service Repair Manual Application: 2004 2005 2006 Yamaha Marine Outboard 70HP (70-HP) 2-Stroke Engines. Model name 70BETO, USA and Canada name 70TR 70C (70-C).

LIT-18616-02-66 Service Repair Manual Application: 2004 2005 2006 Yamaha Marine Outboard 90HP (90-HP) 2-Stroke Engines. Model name 90AETO, USA and Canada name 90TR 90C (90-C).

LIT-18616-02-72 Service Repair Manual Application: 2004-2005-2006 Yamaha Marine Outboard 130HP & 115HP (115C 130C) 2-Stroke Engines. Model Name: 115CETO (115-CETO), 130BETO (130-BETO) 115TR, 130TR.

LIT-18616-02-51 Service Repair Manual Application: 2004, 2005, 2006 Yamaha Marine Outboard 150HP (150-HP) F150C & LF150C (LF-F-150C-F150-C) 4-Stroke Engines. Model name F150TR, LF150TR (F-LF-150-TR)

LIT-18616-02-71 Service Repair Manual Application: 2004, 2005, 2006 Yamaha Marine Outboard 115HP (115-HP) 4-Stroke Engines. Model name F115AET LF115AET, USA and Canada name F115TR LF115TR.

LIT-18616-02-73 Service Repair Manual Application: 2004-2005-2006 Yamaha Marine Outboard 150 HP (150HP) 150C & V150C 2-Stroke Engines. Model Name: 150FETO, 150GETO.

LIT-18616-02-66 Service Repair Manual Application: 2004 2005 2006 Yamaha Marine Outboard 60HP (60-HP) 2-Stroke Engines. Model name 60FETO USA and Canada name 60TR, 60C (60-C).

LIT-18616-02-76 Service Repair Manual Application: 2004-2006 Yamaha Marine Outboard F200C, LF200C, F225C, LF225C 200HP (200-HP) & 225HP (225-HP) V6 4-Stroke Engines.

LIT-18616-02-85 Service Repair Manual Application: 2005-2006 Yamaha Marine Outboard 50HP & 60HP (50-HP, 60-HP) 4-Stroke Engines F50D T50D F60D T60D (F-50-D, T-50-D, F60-D, T60-D).

LIT-18616-02-86 Service Repair Manual Application: 2005-2006 05-06' Yamaha Marine Outboard F90D 90HP 4-Stroke Engines. Model Name F90TR




115TLR 6E5-1014963

 115TLR 6E5-1018223

 115TLR 6E5-1021119

 115TLR 6N6-1018223

 115TXR 6E5-1014963

 150TXR 6G4-1015800

 150TXR 6G4-1017561

 150TXR 6G4-1019349

 15MSH 684K-1038247

 15MSH 684K-1048514

 15MSH 684K-1058763

 25ELH 6L2K-1011699

 25ELH 6L2K-1018361

 25ELH 6L2K-1027048

 25ELR 6L2K-1011699

 25ELR 6L2K-1018361

 25ELR 6L2K-1027048

 25ESH 6L2K-1011699

 25ESH 6L2K-1018361

 25ESH 6L2K-1027048

 25ESR 6L2K-1018361

 25ESR 6L2K-1027048

 25MLH 6L2K-1011699

 25MLH 6L2K-1018361

 25MLH 6L2K-1027048

 25MSH 6L2K-1011699

 25MSH 6L2K-1018361

 25MSH 6L2K-1027048

 40TLR 6H4K-1009495

 50TLR 62X-1013173

 50TLR 6H5K-1007174

 50TLR 6H5K-1013173

 50TLR 6H5K-1021187

 60TLR 6H2K-1005455

 70TLR 6H3-1007285

 70TLR 6H3K-1004863

 70TLR 6H3K-1010213

 8MSH 6N0-1014051

 8MSH 6N0-1019326

 8MSH 6N0-1023676

 8MSH 6N0-1040511

 8MSH 6N0S-1015051

 9.9MSH 682K-1025590

 9.9MSH 682K-1032687
  9.9MSH 682K-1040158

 90TLR 6H1-1022121

 90TLR 6H1-1028291

 90TLR 6H1-1035287

 LZ150TXR 6K0-1000996

 LZ200TXR 6K1-1004053

 LZ200TXR 6K1-1005102

 LZ200TXR 6K1-1006029

 LZ250TXR 60W-1001537

 LZ300TUR 6D1-1001546

 LZ300TXR 6D1-1001546

 LZ300TXR 6D1-1001809

 V150TLR 6J9-1009041

 V150TLR 6J9-1010914

 V150TLR 6J9-1012795

 VZ150TLR 6J9-1009041

 VZ150TLR 6J9-1010914

 VZ150TLR 6J9-1012795

 VZ175TLR 62H-1000920

 VZ175TLR 62H-1001299

 VZ175TLR 62H-1001633

 VZ200RTLTR 6P5-1003473

 VZ200TLR 6P5-1000932

 VZ200TLR 6P5-1002109

 VZ225HTLR 60Y-1005852

 VZ225TLR 60Y-1003330

 VZ225TLR 60Y-1004590

 VZ250FTLR 60X-1005363

 VZ250TLR 60X-1002505

 VZ250TLR 60Y-1003854

 VZ300BTLR 6C9-1001078

 VZ300TLR 6C9-1000648

 VZ300TLR 6C9-1001027

 Z150TXR 6G4-1015800

 Z175TXR 6G5-1000879

 Z200TLR 6P4-1000316

 Z200TXR 6G6-1024935

 Z200TXR 6G6-1028945

 Z200TXR 6G6-1032843

 Z250TXR 60V-1003974

 Z300TUR 6D0-1003215

 Z300TXR 6D0-1003215

 Z300TXR 6D0-1003785
 
 F115TJR 68V-1047408

 F115TJR 68V-1066827

 F115TJR 68V-1082891

 F115TLR 68V-1047408

 F115TLR 68V-1066827

 F115TLR 68V-1082891

 F115TXR 68V-1047408

 F115TXR 68V-1066827

 F115TXR 68V-1082891

 F150TLR 63P-1029405

 F150TLR 63P-1049287

 F150TLR 63P-1069194

 F150TXR 63P-1029405

 F150TXR 63P-1049287

 F150TXR 63P-1069194

 F15CELH 6AGK-1000001

 F15CELH 6AGK-1005906

 F15CESH 6AGK-1000001

 F15CESH 6AGK-1005906

 F15CMLH 6AGK-1000001

 F15CMLH 6AGK-1005906

 F15CMSH 6AGK-1000001

 F15CMSH 6AGK-1005906

 F15CPLH 6AGK-1000001

 F15CPLH 6AGK-1005906

 F15ELH 66M-1019525

 F15ELH 66MK-1000001

 F15ESH 66M-1019525

 F15ESH 66MK-1000001

 F15MLH 66M-1019525

 F15MLH 66MK-1000001

 F15MSH 66M-1019525

 F15MSH 66MK-1000001

 F15PLH 66M-1019525

 F15PLH 66MK-1000001

 F15PLR 66M-1019525

 F15PLR 66MK-1000001

 F2.5MSH 69M-1025804

 F2.5MSH 69M-1033504

 F200TXR 60L-1005828

F200TXR 60L-1008346

 F200TXR 60L-1009954

 F20ELH 6AHK-1000001

 F20ELH 6AHK-1008551

 F20ELR 6AHK-1000001

 F20ELR 6AHK-1008551

 F20ESH 6AHK-1000001

 F20ESH 6AHK-1008551

 F20ESR 6AHK-1000001

 F20ESR 6AHK-1008551

 F20MLH 6AHK-1000001

 F20MLH 6AHK-1008551

 F20MSH 6AHK-1000001

 F20MSH 6AHK-1008551

 F20PLH 6AHK-1000001

 F20PLH 6AHK-1008551

 F20PLR 6AHK-1000001

 F20PLR 6AHK-1008551

 F225TLR 6BB-1000001

 F225TUR 69J-1021983

 F225TXR 69J-1021983

 F225TXR 69J-1027875

 F225TXR 69J-1029406

 F250TUR 6P2-1002899

 F250TUR 6P2-1011652

 F250TUR 6P2-1021904

 F250TXR 6P2-1002895

 F250TXR 6P2-1011652

 F250TXR 6P2-1021904

 F25ELH 65W-1025569

 F25ELR 65W-1025569

 F25ESH 65W-1025569

 F25ESR 65W-1025569

 F25MLH 65W-1025569

 F25MSH 65W-1025569

 F25TLR 65W-1025569

 F300TUR 6BJ-1000001

 F300TXR 6BJ-1000001

 F30TLR 69H-1004353

 F350TUR 6AW-1000001

 F350TXR 6AW-1000001

 F40BEJR 67C-1036313

 F40BMJH 67C-1036313

 F40BMLH 67C-1036313

 F40BTLR 67C-1036313

 F40EJR 67C-1019712

 F40EJR 67C-1028012

 F40MJH 67C-1019712

 F40MJH 67C-1028012

 F40MLH 67C-1019712

 F40MLH 67C-1028012

 F40MSH 67C-1019712

 F40TLR 67C-1019712

 F40TLR 67C-1028012

 F4MLH 68D-1037012

 F4MLH 68D-1051455

 F4MLH 68D-1065145

 F4MSH 68D-1037012

 F4MSH 68D-1051455

 F4MSH 68D-1065145

 F50TLR 6C1-1006373

 F50TLR 6C1-1012527

 F50TLR 6C1-1036313

 F60TJR 6C5-1007597

 F60TJR 6C5-1016449
  F60TJR 6C5-1025302

 F60TLR 6C5-1007597

 F60TLR 6C5-1016449

 F60TLR 6C5-1025302

 F6AMLH 60N-1008336

 F6AMSH 60N-1008336

 F6MLH 60N-1002466

 F6MLH 60N-1005231

 F6MSH 60N-1002466

 F6MSH 60N-1005231

 F75TLR 62P-1005583

 F75TLR 62P-1008069

 F75TLR 62P-1010402

 F8CMLH 60R-1015181

 F8CMSH 60R-1015181

 F8MLH 60R-1004281

 F8MLH 60R-1008881

 F8MSH 60R-1004281

 F8MSH 60R-1008881

 F9.9ELR2 66N-1004576

 F9.9ELR2 66NK-1000001

 F9.9ELR2 66NK-1001710

 F9.9FELR 6AUK-1000001

 F9.9FMLH 6AUK-1000001

 F9.9FMSH 6AUK-1000001

 F9.9MLH2 66N-1004576

 F9.9MLH2 66NK-1000011

 F9.9MLH2 66NK-1001710

 F9.9MSH2 66N-1004576

 F9.9MSH2 66NK-1000001

 F9.9MSH2 66NK-1001710

 F90TJR 61P-1013277

 F90TJR 61P-1021936

 F90TJR 61P-1028830

 F90TLR 61P-1013277

 F90TLR 61P-1021936

 F90TLR 61P-1028830

 F90TXR 61P-1013277

 F90TXR 61P-1021936

 F90TXR 61P-1028830

 LF115TXR 68W-1002054

 LF115TXR 68W-1002955

 LF115TXR 68W-1003581

 LF150TXR 64P-1003507

 LF150TXR 64P-1006749

 LF150TXR 64P-1009682

 LF200TXR 60M-1000986

 LF200TXR 60M-1001344

LF200TXR 60M-1001529

 LF225TUR 69K-1006907

 LF225TXR 69K-1006907

 LF225TXR 69K-1008434

 LF225TXR 69K-1008932

 LF250TUR 6P3-1000957

 LF250TUR 6P3-1005453

 LF250TUR 6P3-1009546

 LF250TXR 6P3-1000957

 LF250TXR 6P3-1005453

 LF250TXR 6P3-1009546

 LF300TUR 6BK-1000001

 LF300TXR 6BK-1000001

 LF350TUT 6AX-1000001

 LF350TXR 6AX-1000001

 T25TLR

 T25TLR 65W-1025569

 T50TLR 6C2-1001851

 T50TLR 6C2-1004629

 T50TLR 6C2-1006660

 T60TLR 6C6-1002114

 T60TLR 6C6-1005083

 T60TLR 6C6-1008344

 T8DELH 60S-1018941

 T8DEXH 60S-1018941

 T8DPLH 60S-1018941

 T8DPLR 60S-1018941

 T8DPXH 60S-1018941

 T8DPXR 60S-1018941

 T8ELH 60S-1006138

 T8ELH 60S-1012688

 T8EXH 60S-1006138

 T8EXH 60S-1012688

 T8PLH 60S-1006138

 T8PLH 60S-1012688

 T8PLR 60S-1006138

 T8PLR 60S-1012688

 T8PXH 60S-1006138

 T8PXH 60S-1012688

 T8PXR 60S-1006138

 T8PXR 60S-1012688

 T9.9ELH2 66R-1003498

 T9.9ELH2 66RK-1000001

 T9.9ELH2 66RK-1001153

 T9.9ELR2 66R-1003498

 T9.9ELR2 66RK-1000001

 T9.9ELR2 66RK-1001153

 T9.9EXH2 66R-1003498

 T9.9EXH2 66RK-1000001

 T9.9EXH2 66RK-1001153

 T9.9GELH 6AVK-1000001

 T9.9GEXH 6AVK-1000001

 T9.9GPLH 6AVK-1000001

 T9.9GPLR 6AVK-1000001

 T9.9GPXH 6AVK-1000001

 T9.9GPXR 6AVK-1000001